$1 million BYU project may save A.F. millions

PROVO — Test pilots might have equipment developed at Brigham Young University on board when they begin tests of the new Joint Strike Fighter jet next year at Edwards Air Force Base in California.

The Department of Defense has committed nearly $1 million to a promising BYU project that might clean up garbled data transmissions that have plagued test flights for nearly two decades.

Barrel rolls and bandwidth problems have made it difficult for the Flight Test Center at the base to cleanly capture the massive streams of data generated about a plane's performance during each test flight and sent from antennas on the plane to a receiver on the ground.

When the information is scrambled, the expensive tests must be repeated. "The military has to put each airplane through a series of maneuvers to test the stresses, the strains and the temperatures it might experience so when the plane is in combat and flies dozens of sorties, it won't break down," said Michael Rice, the BYU professor who developed the solution to the data dilemma.

The 412th Test Wing at Edwards still attaches a single antenna to the bottom of many of the planes it tests, but the signal to the receiver is often blocked when the plane banks away or turns over, breaking the link between the antenna and the ground receiver.

A second antenna is added to the top of the planes for most test flights now, and both antennas send the same signal back to the ground. But that apparent solution stopped working when the planes and their weapon systems grew so complex that the amount of information overwhelmed the signals.

"When the data rates are low, the second antenna works fine," Rice said. "It's when the data rates get high that the signals interfere with each other. The border is about 5 megabits per second."

That's far more flight information — or telemetry — than Apollo spacecraft sent back to Earth during missions to the moon in the 1960s and '70s.

"Fighter airplanes today are more sophisticated than those moon landings were," Rice said. "In the movie 'Apollo 13,' you saw rows and rows of engineers with pocket protectors and black glasses monitoring numbers rolling across their screens. Each screen and engineer was dedicated to one thing, like battery levels or astronaut vital signs.

"Our contract is to build a piece of hardware that receives similar data in real time for monitoring by test engineers."